2025 Chevrolet Corvette Safety Report

Service Brakes

1 owner complaint mention this component in the current safety profile.

Seats

1 owner complaint mention this component in the current safety profile.

Power Train,Engine

1 owner complaint mention this component in the current safety profile.

Unknown Or Other

1 owner complaint mention this component in the current safety profile.

Fuel System, Gasoline

1 owner complaint mention this component in the current safety profile.

Wheels

1 owner complaint mention this component in the current safety profile.

Issues with service brakes have been reported, affecting 23% of the vehicles.

Malfunctioning forward collision avoidance alerts have been reported, affecting 15% of the vehicles.

Fuel system issues have been reported, affecting 10% of the vehicles.

Seat belt retractor issues have been reported, affecting 5% of the vehicles.

Summary: General Motors, LLC (GM) is recalling certain 2023–2026 Chevrolet Corvette vehicles equipped with a left-side radiator/fan combination. Excess fuel may spill into the vehicle fuel-filler pocket during refueling and leak onto an ignition source.

Consequence: A fuel leak in the presence of an ignition source, such as hot engine or exhaust components, can increase the risk of a fire.

Remedy: Dealers will install a shield to divert spilled fuel, free of charge. Owner notification letters were mailed November 14, 2025. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N252514930.

Summary: General Motors, LLC (GM) is recalling certain 2024-2025 Chevrolet Corvette vehicles. The driver and/or passenger seat belt retractors may lock in a stowed position and become inaccessible to occupants.

Consequence: An inaccessible seat belt that cannot restrain an occupant, increases the risk of injury in a crash.

Remedy: Dealers will replace the driver and/or passenger seat belt retractors, free of charge. Owner notification letters were mailed September 19, 2024. Owners may contact Chevrolet customer service at 1-800-222-1020. GM's number for this recall is N242441390.

On 3/21/2026 @ approximately 1:45 PM I was driving down a local road @ approximately 25MPH. While approaching a stop sign, I attempted to stop the vehicle, I applied the brakes and the brake pedal dropped serval inches and became hard felt like it hit the floor of the vehicle. The vehicle continued through the intersection. **There was NO warning message before the vehicle brakes failed to functio...

The contact owns a 2025 Chevrolet Corvette. The contact stated that there was a strong chemical odor coming from the seats. The contact had experienced headaches, burning eyes, respiratory issues, and inflamed lungs. The contact stated that he had temporarily stopped driving the vehicle, and upon driving the vehicle a month later, the contact became aware that the strong chemical odor was the caus...

Intermittent drivability issue involving the transmission during takeoff from a complete stop, most noticeable in heavy traffic and stop and go conditions. Vehicle shudders and lurches when accelerating from a dead stop, with a sensation similar to being hit from behind followed by abrupt engagement. This creates unpredictable launch behavior and raises concern for safe acceleration in traffic, in...

Water trapped under vehicle and in the doors of the vehicle!

The contact owns a 2025 Chevrolet Corvette. The contact received notification of NHTSA Campaign Number: 25V536000 (Fuel System, Gasoline); however, the part for the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact called a local dealer and was advised to bring the vehicle to their location, and...

When having the stock tires changed to all-season tires, the technician found a rear wheel with 2 cracks in the inside bead area. Car had about 8500 miles and an inspection of the old tires showed no damage to the tread or sidewall. No leaking had been noted.

The contact owns a 2025 Chevrolet Corvette. The contact stated that while operating the vehicle, the Forward Collision Avoidance alert button was pressed but the Forward Collision Avoidance system failed to activate. The cause of the failure was not yet determined, and the vehicle was not repaired. The local dealer was made aware of the failure. The manufacturer was not yet contacted. The failure ...

Please refer to Part 573 Safety Recall Report 25V536. This report seeks to bring to the attention of the NHTSA that additional General Motors, LLC Chevrolet Corvette Models NOT INCLUDED in the Recall Report are virtually identical in design and having the identical safety issue. THE ISSUE: Excess fuel spilled into the fuel filler pocket drains directly into the left-side fan equipped air intake. T...

The contact owns a 2025 Chevrolet Corvette. The contact stated that the rear glass had a one-inch gap, allowing heat to escape the vehicle, and allowing water to enter the engine compartment and inside the vehicle. While the contact was driving at undisclosed speeds in the rain, there was water entering the vehicle. There were no warning lights illuminated. The local dealer was contacted and deter...

Service Updated - Certain vehicles listed above may have a condition in which the Body Control Module (BCM) may not properly clear the DTC U1962 (Unable to Authenticate Serial Data Message). Dealers are to reprogram the body control module.

This service bulletin provides repair information to correct a customer concern of Service Instrument Cluster DIC Message Caused by DTC U3000 SYM 09.

• Improvements to emergency parking brake functionality • Improves propulsion system performance and overall drive quality • Fixes implemented to correct inaccurate activation of check engine light • Improves eTrunk emergency release switch operation • Reduces noise levels when shifting • Fixes...

Great News! Your vehicle keeps getting better. This update contains a required software change to help improve the overall software update and diagnostics process. Be sure to install this update to be able to receive future software updates. Better Never Stops™

This service bulletin provides a Diagnostic Aid for PicoScope Information and Setup for Transmission Related Concerns.

This service bulletin advises the technician of possible coolant entering the areas of the engine, either through failed parts or defects in the castings, that may be the cause of the concerns related to the MIL or the engine running rough.

This bulletin provides information on identifying Non-GM Engine Calibrations for Gasoline Engines using the Tech 2 or GDS 2.

This service bulletin provides information to correct a customer concern of Check Engine Light or Malfunction Indicator Lamp Illuminated with DTCs U0401 and/or U1611 Set.

This Preliminary information communicates recovery procedure after return to dealer message.

This Preliminary information communicates a diagnostic tip on how to resolve a issue if the serial data authentication configuration did not complete correctly.

This Preliminary information communicates diagnostic tips on how to resolve a issues with vehicles that will not power up after a can bus 2 issue, lightning strike, or a failed over the air update.

This Preliminary Information communication advises the technician on the need to provide additional information when creating a TAC case for a DCT transmission

This warranty administration bulletin provides policy information for GM courtesy transportation and roadside assistance programs.

This warranty administration bulletin provides policy information on the requirements for 12V battery testing and warranty replacements.

This service bulletin informs the technician on the running changes to the M1L, M1M, MLH automatic transmissions.

This service bulletin informs the technician that there are multiple drain plugs that need to be removed in order to drain all the oil from the engine.

This service bulletin provides information for dealers/technicians on Labor Operations for Limited Production Option (LPO) Calibrated Accessories.

This warranty bulletin provides information on Customer Concern Not Duplicated (CCND) Labor Operation Numbers.

This warranty administration bulletin provide policy information for variable diagnostic time allowances on select labor operations (U.S. Only).

This service bulletin provides information on the Transport Mode Feature, also known as Logistics mode, which is used to increase the 12V Battery stand time of the vehicle during transit and or long period of stand time at the dealerships.