2021 Volvo Vnr Safety Report
2021 VOLVO VNR Safety Report
Safety Decision Cockpit for the 2021 Volvo Vnr
This page is the hub for deciding what to inspect next on the 2021 Volvo Vnr. It connects recall campaigns, owner complaint patterns, service bulletins, sibling model years, component issue hubs, and the model buying guide so a shopper or owner can move from a single report into the wider safety graph.
| Signal | Value | What to inspect next |
|---|---|---|
| Recall burden | High (8) | Review campaign numbers, affected components, and dealer remedies below. |
| Owner complaints | Low (1) | Scan complaint narratives for recurring symptoms, mileage, crashes, fires, injuries, and dates. |
| Crash and fire reports | 0 | Treat any crash, fire, injury, or fatality-linked pattern as a priority pre-purchase inspection item. |
| Primary component hub | Unknown Or Other,Visibility/Wiper | Compare unknown or other,visibility/wiper issues across vehicles. |
| Cleaner nearby model year | 2023 | Compare against the 2023 Volvo Vnr with 1 complaints and 3 recalls. |
Volvo Vnr Year-by-Year Comparison
The safest purchase decision usually comes from comparing neighboring model years, not reading a single page in isolation. The table below uses only validated Volvo Vnr years already present in the cleaned NHTSA dataset, so each comparison links to a real vehicle safety report rather than a generated combination.
| Model Year | Complaints | Recalls | Use case |
|---|---|---|---|
| 2023 Volvo Vnr | 1 | 3 | Use as a comparable safety baseline. |
2021 Volvo Vnr Complaint Theme Map
Complaint counts become more useful when they are grouped into inspection themes. For the 2021 Volvo Vnr, these are the component areas with the clearest NHTSA complaint signals. Use each link to jump from this single vehicle into broader component hubs and make-specific issue pages.
Unknown Or Other,Visibility/Wiper
1 owner complaint mention this component in the current safety profile.
All Unknown Or Other,Visibility/Wiper issues Volvo onlyAI Safety Analysis for the 2021 Volvo Vnr
Reliability Score
The 2021 Volvo Vnr receives a reliability score of 85 out of 100 based on analysis of NHTSA complaint data, recall history, crash reports, and safety ratings. This indicates above-average reliability relative to comparable vehicles.
Known Issues for the 2021 Volvo Vnr
The following issues have been identified from NHTSA complaint data and owner reports for the 2021 Volvo Vnr:
| Issue | Severity | Frequency | Typical Mileage |
|---|---|---|---|
| Propulsion System, Traction Battery, Thermal Management Volvo is recalling certain 2020-2024 VNR Electric vehicles due to issues with the propulsion system, traction battery, and thermal management. |
Medium | Rare | 30k-60k miles |
| Vehicle Controls, Braking Systems Volvo is recalling certain 2020-2023 VNR Electric vehicles for issues with vehicle controls and braking systems. |
Medium | Rare | 30k-60k miles |
| Wheels, Hub, Steering Volvo is recalling 2021-2022 VAH, VDH, VNL, and VNR vehicles for issues with wheels, hub, and steering. |
Medium | Rare | 30k-60k miles |
| Service Brakes, Hydraulic And Air Volvo is recalling 2020-2021 VAH, VHD, VNL, and VNR vehicles for issues with service brakes, hydraulic and air. |
Medium | Rare | 30k-60k miles |
Common Problems Reported by Owners
Based on NHTSA complaint data, the following components account for the majority of reported issues with the 2021 Volvo Vnr:
Issues with the propulsion system, traction battery, and thermal management are common in certain 2020-2024 VNR Electric vehicles.
Recall Details for the 2021 Volvo Vnr
The following 8 recalls have been issued for the 2021 Volvo Vnr by NHTSA:
Summary: Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2024 VNR Electric vehicles. The coolant line in the high voltage battery pack may not be fully seated and locked, which can result in the loss of coolant and an electrical short circuit.
Consequence: A battery short circuit increases the risk of a fire.
Remedy: Volvo Trucks will work with the battery manufacturer Akasol to inspect and replace the batteries, as necessary, free of charge. Owner notification letters were mailed May 9, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Truck's number for this recall is RVXX 2304.
Summary: Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2023 VNR Electric vehicles equipped with Adaptive Cruise Control (ACC). When the adaptive cruise control braking activates under light load conditions, it can trigger an aggressive braking response.
Consequence: Overly aggressive braking can result in the rear axle skidding, the brakes locking up, and/or a loss of vehicle control, increasing the risk of a crash.
Remedy: Dealers will secure wiring and remove radar antennas and brackets from the vehicle. The anti-lock braking system will be reprogrammed to disable adaptive cruise control. Owner notification letters are expected to be mailed June 2, 2023. Owners may contact Volvo Trucks' customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2303.
Summary: Volvo Trucks North America (Volvo Trucks) is recalling certain 2021-2022 VAH, VDH, VNL, AND VNR vehicles. The hubcap compression spring can cause the hubcap to separate.
Consequence: A separated hubcap can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will remove the hubcap, free of charge. Owner notification letters were mailed on July 12, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Mack's number for this recall is RVXX 2102.
Summary: Volvo Trucks North America (Volvo Trucks) is recalling 2021 VNL, VNR, VAH, and VHD vehicles. The collets (internal jaws) for the brass fitting inserts used in the pneumatic pass-through plate may have been damaged during leak testing. As a result, the brass fitting may completely release the air brake line from the pass-through plate while under pressure. If this occurs on the park brake circuit, signal pressure that holds off the mechanical spring in the park brake chambers will be lost allow...
Consequence: If the park brakes apply unexpectedly, the driver may lose control of the vehicle, increasing the risk of a vehicle crash.
Remedy: Volvo Trucks will notify owners, and dealers will inspect the air brake line for proper engagement of the fitting in the pass-through plate, free of charge. The recall is expected to begin January 31, 2021. Owners may contact Volvo Trucks customer service at 1-800-528-6586. Volvo Trucks' number for this recall is RVXX2006.
Summary: Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2021 VAH, VHD, VNL and VNR vehicles. The die cast pedal plate may break at one of its attachment points, possibly resulting in the brake pedal dislodging. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 121, "Air Brake Systems."
Consequence: A dislodged brake pedal would be inoperable, increasing a risk of a crash.
Remedy: Volvo Trucks will notify owners, and dealers will inspect and replace the pedal plates if required, free of charge. The recall began October 7, 2020. Owners may contact Volvo Trucks customer service at 1-800-458-1552. Volvo Truck's number for this recall is RVXX2004.
Summary: Volvo Trucks North America (Volvo Trucks) is recalling certain 2021 VNL, VHD, and VNR vehicles. The king pin nut may not have been installed or properly tightened during axle assembly.
Consequence: If the king pin is missing or not tightened properly, the knuckle may separate from the axle, increasing the risk of a crash.
Remedy: Volvo Trucks will notify owners, and dealers will inspect the vehicle to make sure that the king pin nut is installed and that it properly tightened, free of charge. The recall began September 28, 2020. Owners may contact Volvo Trucks customer service at 1-800-458-1522. Volvo Truck's number for this recall is RVXX 2003.
Summary: Volvo Trucks North America (Volvo) is recalling certain 2018-2021 VNL and VNR buses. The Gross Axle Weight Rating (GAWR) for the rear drive axles stated on the Federal Certification Label exceeds the rating of the wheel hubs. As such, these vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification."
Consequence: If the rear axles are overloaded, over time the wheel hubs may fail prematurely, increasing the risk of a crash.
Remedy: Volvo will notify owners and send corrected replacement labels, free of charge. The recall began August 18, 2020. Owners may contact Volvo customer service at 1-800-528-6586. Volvo's number for this recall is RVXX2002.
Summary: Volvo Trucks North America (Volvo Trucks) is recalling certain 2020-2021 VNL and VNR trucks. The steering gear fasteners may have not been properly tightened.
Consequence: The loose fasteners may result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Volvo Trucks will notify owners, and dealers will tighten the steering gear fasteners to specification, free of charge. The recall began May 20, 2020. Owners may contact Volvo Trucks customer service at 800-528-6586. Volvo Trucks' number for this recall is RVXX2001.
NHTSA Complaint Summaries for the 2021 Volvo Vnr
Below are complaint narratives filed by owners of the 2021 Volvo Vnr with the National Highway Traffic Safety Administration.
This Is a volvo semi tractor 2021 the original sunvisor was removed from tractor. And an off brand replacement was installed which is substantially smaller by 4 inches on each side of visor + it's mounted in wrong direction making morning and evening's very difficult due too extremely bright glares from sun even head lights Led signage. It's a danger I don't like ! Bike lanes,people crossing the...
Frequently Asked Questions About the 2021 Volvo Vnr
Has the 2021 VOLVO VNR been recalled?
Yes, the 2021 VOLVO VNR has 8 recalls on record with NHTSA. Each recall addresses a specific safety defect identified by the manufacturer or NHTSA.
How many complaints does the 2021 VOLVO VNR have?
The 2021 VOLVO VNR has 1 complaint filed with NHTSA. None of the complaints involved crashes. No injuries or deaths have been reported.
What is the safety rating for the 2021 VOLVO VNR?
The 2021 VOLVO VNR does not have an NHTSA safety rating on file. This can happen for newer model years, specialty vehicles, or models that have not been crash-tested.
What are the most common problems with the 2021 VOLVO VNR?
The most commonly reported problems with the 2021 VOLVO VNR involve unknown or other,visibility/wiper (1 complaints).
How many crash reports does the 2021 VOLVO VNR have?
There are no crash reports associated with the 2021 VOLVO VNR in the NHTSA database.
How many fire reports does the 2021 VOLVO VNR have?
There are no fire reports for the 2021 VOLVO VNR in the NHTSA database.
Are there any deaths reported for the 2021 VOLVO VNR?
No deaths have been reported in NHTSA complaints for the 2021 VOLVO VNR.
How many injuries are reported for the 2021 VOLVO VNR?
No injuries have been reported in NHTSA complaints for the 2021 VOLVO VNR.
Should I buy a 2021 VOLVO VNR?
Based on NHTSA data, the 2021 VOLVO VNR is research thoroughly before purchasing. It has 1 complaints, 8 recalls. Always have a pre-purchase inspection done by a qualified mechanic.
What components fail most on the 2021 VOLVO VNR?
The components with the most failures on the 2021 VOLVO VNR are: 1. UNKNOWN OR OTHER,VISIBILITY/WIPER (1 complaints). UNKNOWN OR OTHER,VISIBILITY/WIPER is the single most-reported problem area with 1 complaints.
What should I know before buying a 2021 VOLVO VNR?
Ensure your 2021 VOLVO VNR is up to date with all recalls and consider professional installation of sun visors for optimal visibility. The 2021 VOLVO VNR has 1 NHTSA complaints and 8 recalls on record.
How reliable is the 2021 VOLVO VNR?
The 2021 VOLVO VNR receives a reliability score of 85/100, indicating above-average reliability. This is based on 1 owner complaints, 8 recalls, and 0 crash/fire reports in the NHTSA database. Key known issues include Propulsion System, Traction Battery, Thermal Management and Vehicle Controls, Braking Systems.
What are the known issues with the 2021 VOLVO VNR?
Known issues with the 2021 VOLVO VNR include: Propulsion System, Traction Battery, Thermal Management, Vehicle Controls, Braking Systems, Wheels, Hub, Steering, Service Brakes, Hydraulic and Air. These are based on patterns found across 1 NHTSA complaints. 8 of these patterns resulted in formal recalls.
Are there any recalls for the 2021 VOLVO VNR?
Yes, there are recalls for propulsion system, traction battery, and thermal management issues.
What are the common issues with the 2021 VOLVO VNR?
Common issues include propulsion system, traction battery, and thermal management problems.
Should I replace the sun visor myself?
It's recommended to have a professional install the sun visor for optimal performance.
Buyer Advice
Our recommendation: Ensure your 2021 VOLVO VNR is up to date with all recalls and consider professional installation of sun visors for optimal visibility.
NHTSA Data Summary for 2021 Volvo Vnr
This safety report is based on a comprehensive analysis of data from the National Highway Traffic Safety Administration (NHTSA) for the 2021 Volvo Vnr. The data includes 1 consumer complaints filed by vehicle owners, 8 manufacturer-initiated safety recalls, and safety rating assessments associated with this vehicle.
All data presented in this report is sourced from public NHTSA databases. Our AI analysis identifies patterns across complaint narratives, correlates them with recall history, and produces the safety assessment above. This analysis is updated as new complaints and recalls are filed with the NHTSA.
Consumers are encouraged to report vehicle safety problems to the NHTSA at nhtsa.gov. If your vehicle is subject to a recall, contact your dealer to schedule the free repair.
Disclaimer: This analysis is AI-generated from NHTSA public data and does not constitute professional automotive or safety advice. Always verify recall status at NHTSA.gov and consult a qualified mechanic.
Analysis last updated: 2026-05-17