2015 Bmw 640i Safety Report
2015 BMW 640I Safety Analysis
Safety Decision Cockpit for the 2015 Bmw 640i
This page is the hub for deciding what to inspect next on the 2015 Bmw 640i. It connects recall campaigns, owner complaint patterns, service bulletins, sibling model years, component issue hubs, and the model buying guide so a shopper or owner can move from a single report into the wider safety graph.
| Signal | Value | What to inspect next |
|---|---|---|
| Recall burden | Moderate (1) | Review campaign numbers, affected components, and dealer remedies below. |
| Owner complaints | Low (4) | Scan complaint narratives for recurring symptoms, mileage, crashes, fires, injuries, and dates. |
| Crash and fire reports | 1 | Treat any crash, fire, injury, or fatality-linked pattern as a priority pre-purchase inspection item. |
| Primary component hub | Wheels | Compare wheels issues across vehicles. |
| Cleaner nearby model year | 2019 | Compare against the 2019 Bmw 640i with 2 complaints and 1 recalls. |
Bmw 640i Year-by-Year Comparison
The safest purchase decision usually comes from comparing neighboring model years, not reading a single page in isolation. The table below uses only validated Bmw 640i years already present in the cleaned NHTSA dataset, so each comparison links to a real vehicle safety report rather than a generated combination.
| Model Year | Complaints | Recalls | Use case |
|---|---|---|---|
| 2019 Bmw 640i | 2 | 1 | Compare as a potentially cleaner alternative. |
2015 Bmw 640i Complaint Theme Map
Complaint counts become more useful when they are grouped into inspection themes. For the 2015 Bmw 640i, these are the component areas with the clearest NHTSA complaint signals. Use each link to jump from this single vehicle into broader component hubs and make-specific issue pages.
Wheels
2 owner complaints mention this component in the current safety profile.
All Wheels issues Bmw onlyStructure
1 owner complaint mention this component in the current safety profile.
All Structure issues Bmw onlyElectrical System,Service Brakes,Engine
1 owner complaint mention this component in the current safety profile.
All Electrical System,Service Brakes,Engine issues Bmw onlyAI Safety Analysis for the 2015 Bmw 640i
Reliability Score
The 2015 Bmw 640i receives a reliability score of 87 out of 100 based on analysis of NHTSA complaint data, recall history, crash reports, and safety ratings. This indicates above-average reliability relative to comparable vehicles.
Known Issues for the 2015 Bmw 640i
The following issues have been identified from NHTSA complaint data and owner reports for the 2015 Bmw 640i:
| Issue | Severity | Frequency | Typical Mileage |
|---|---|---|---|
| Airbag Inflator Module BMW is recalling certain 2015 6 Series Gran Coupe, 2014 5 Series Gran Turismo models due to potential issues with the airbag inflator module. |
Medium | Common | 30k-60k miles |
| Tire Separation Tires blew out due to separation right under the rim, still under warranty, but Goodyear Dunlop tires have shown this defect. |
High | Common | 11,000-15,000 miles |
| Driver Side Door Driver side door opens on its own, will not stay shut, and has been repaired four times without success. |
Medium | Occasional | N/A miles |
| Engine Light Engine light has been observed to come on, but no specific issues have been identified. |
Low | Common | N/A miles |
Common Problems Reported by Owners
Based on NHTSA complaint data, the following components account for the majority of reported issues with the 2015 Bmw 640i:
Tires have shown signs of separation and blowouts, especially under warranty.
Recalled due to potential issues with the airbag inflator module.
Driver side door has been problematic, opening on its own and not staying shut.
Third rear brake light is leaking due to failed seals and clips.
Recall Details for the 2015 Bmw 640i
The following 1 recall has been issued for the 2015 Bmw 640i by NHTSA:
Summary: BMW of North America, LLC (BMW) is recalling certain 2015 6 Series Gran Coupe, 2014 5 Series Gran Turismo, 2014 5 Series Sedan, 2015 6 Series Convertible, 2015 6 Series Coupe, 2014 X5, 2013-2014 X3, 2014-2015 3 Series Sedan, 2014 4 Series Coupe, 2014 4 Series Convertible, 2014 3 Series Gran Turismo, and 2015 4 Series Gran Coupe vehicles. Please see the recall report for the complete list of models. The driver's air bag inflator may explode during deployment, due to a manufacturing defect.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, increasing the risk of injury or death.
Remedy: The driver's front air bag will be replaced, free of charge. Owner notification letters were mailed September 6, 2024. Owners may contact BMW customer service at 1-800-525-7417.
NHTSA Complaint Summaries for the 2015 Bmw 640i
Below are complaint narratives filed by owners of the 2015 Bmw 640i with the National Highway Traffic Safety Administration. 1 complaint involved crashes. 1 reported injuries or fatalities.
The car is leaking from the third rear brake light (at the rear roof of the car). It appears the seals and possible clips/fasteners have failed and water is entering the car during rain or water immersion from the rear brake light, to the back seat, trunk, and rear floor. There is now visible mold in the car.
THE REAR TIRE WAS LEAKING CAUSING AN UNSAFE ROAD CONDITION. WHEN THE TIRE WAS INSPECTED IT WAS FOUND THAT THE WHEEL HAD A CRACK IN THE SUPPORT DUE TO A DEFECT IN DESIGN. THE DEALER STATES THAT MANY OF THE 5 AND 6 SERIES WITH THIS WHEEL HAVE ISSUES AND OFFERED ME A "WARRANTY PACKAGE" FOR THEM FOR $1700. WHEN DOING RESEARCH ONLINE THIS IS A COMMON PROBLEM AND A CLEAR SAFETY ISSUE. WHEN USED WITH...
THE TIRES BLEW OUT WHILE ON A ROAD TRIP AT APP 11,000 MILES, SEPARATION RIGHT UNDER THE RIM. TIRES ARE STILL UNDER WARRANTY. HOWEVER, GOODYEAR DUNLOP WON'T BE SQUARE WITH WARRANTY, MAKING THE WARRANTY OF NO VALUE. IN FACT THEY LIED ABOUT THE CAUSE AT FIRST. STILL HAVE THE TIRE FOR REVIEW.
DRIVERS SIDE DOOR OPEN ON ITS OWN, WILL NOT STAY SHUT , DEALSHIP HAS BEEN UNABLE TOO FIX IT? SIDE DOOR DOESN'T CLOSE REPAIRED FOUR TIMES . ENGINE LIGHT COME ON? ROOF LATCH NO AIR BAGS WENT OF?DEALSHIP SAYS CODES SAY?THEY DID?
NHTSA Defect Investigations for the 2015 Bmw 640i
NHTSA defect investigations are higher-signal than ordinary complaints because they indicate the agency opened a formal review of a potential safety defect. Some investigations later connect to recall campaigns; others close without a recall after review.
Component: Air Bags:Frontal:Driver Side:Inflator Module
Opened 2021-09-17
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 20...
Frequently Asked Questions About the 2015 Bmw 640i
Has the 2015 BMW 640I been recalled?
Yes, the 2015 BMW 640I has 1 recall on record with NHTSA. Each recall addresses a specific safety defect identified by the manufacturer or NHTSA.
How many complaints does the 2015 BMW 640I have?
The 2015 BMW 640I has 4 complaints filed with NHTSA. Of these, 1 involved crashes. 2 injuries and 0 deaths have been reported.
What is the safety rating for the 2015 BMW 640I?
The 2015 BMW 640I does not have an NHTSA safety rating on file. This can happen for newer model years, specialty vehicles, or models that have not been crash-tested.
What are the most common problems with the 2015 BMW 640I?
The most commonly reported problems with the 2015 BMW 640I involve wheels (2 complaints), structure (1 complaints), electrical system,service brakes,engine (1 complaints).
How many crash reports does the 2015 BMW 640I have?
There are 1 crash reports associated with the 2015 BMW 640I out of 4 total complaints (25.0% of complaints involved crashes).
How many fire reports does the 2015 BMW 640I have?
There are no fire reports for the 2015 BMW 640I in the NHTSA database.
Are there any deaths reported for the 2015 BMW 640I?
No deaths have been reported in NHTSA complaints for the 2015 BMW 640I.
How many injuries are reported for the 2015 BMW 640I?
2 injuries have been reported in NHTSA complaints for the 2015 BMW 640I. These are self-reported by vehicle owners as part of their safety complaints.
Should I buy a 2015 BMW 640I?
Based on NHTSA data, the 2015 BMW 640I is research thoroughly before purchasing. It has 4 complaints, 1 recalls. Always have a pre-purchase inspection done by a qualified mechanic.
What components fail most on the 2015 BMW 640I?
The components with the most failures on the 2015 BMW 640I are: 1. WHEELS (2 complaints), 2. STRUCTURE (1 complaints), 3. ELECTRICAL SYSTEM,SERVICE BRAKES,ENGINE (1 complaints). WHEELS is the single most-reported problem area with 2 complaints.
What should I know before buying a 2015 BMW 640I?
Be cautious of tire separation and ensure regular inspections. Check for recalls and address any ongoing issues with the driver side door promptly. The 2015 BMW 640I has 4 NHTSA complaints and 1 recalls on record.
How reliable is the 2015 BMW 640I?
The 2015 BMW 640I receives a reliability score of 87/100, indicating above-average reliability. This is based on 4 owner complaints, 1 recalls, and 1 crash/fire reports in the NHTSA database. Key known issues include Airbag Inflator Module and Tire Separation.
What are the known issues with the 2015 BMW 640I?
Known issues with the 2015 BMW 640I include: Airbag Inflator Module, Tire Separation, Driver Side Door, Engine Light. These are based on patterns found across 4 NHTSA complaints. 1 of these patterns resulted in formal recalls.
Are there any recalls for the 2015 BMW 640I?
Yes, there is a recall for the airbag inflator module.
What is the issue with the driver side door?
The door opens on its own and has been repaired multiple times without success.
Are the tires under warranty?
Yes, the tires are still under warranty, but there have been issues with separation.
Buyer Advice
Our recommendation: Be cautious of tire separation and ensure regular inspections. Check for recalls and address any ongoing issues with the driver side door promptly.
NHTSA Data Summary for 2015 Bmw 640i
This safety report is based on a comprehensive analysis of data from the National Highway Traffic Safety Administration (NHTSA) for the 2015 Bmw 640i. The data includes 4 consumer complaints filed by vehicle owners, 1 manufacturer-initiated safety recalls, 1 reported crashes, 2 reported injuries, and safety rating assessments associated with this vehicle.
All data presented in this report is sourced from public NHTSA databases. Our AI analysis identifies patterns across complaint narratives, correlates them with recall history, and produces the safety assessment above. This analysis is updated as new complaints and recalls are filed with the NHTSA.
Consumers are encouraged to report vehicle safety problems to the NHTSA at nhtsa.gov. If your vehicle is subject to a recall, contact your dealer to schedule the free repair.
Disclaimer: This analysis is AI-generated from NHTSA public data and does not constitute professional automotive or safety advice. Always verify recall status at NHTSA.gov and consult a qualified mechanic.
Analysis last updated: 2026-05-13