2024 Tesla Cybertruck Safety Report

Structure

28 owner complaints mention this component in the current safety profile.

Unknown Or Other

12 owner complaints mention this component in the current safety profile.

Visibility/Wiper

11 owner complaints mention this component in the current safety profile.

Electrical System

8 owner complaints mention this component in the current safety profile.

Exterior Lighting

6 owner complaints mention this component in the current safety profile.

Forward Collision Avoidance

4 owner complaints mention this component in the current safety profile.

Recall for exterior lighting issues.

Light bar delamination risk.

AC charging performance drops and fails.

All road safety features suddenly stop working.

Summary: Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles equipped with a service-installed off-road light bar accessory. An incorrect surface primer may have been used to attach the lightbar to the windshield, causing the light bar to loosen and detach.

Consequence: A detached light bar may fall, creating a road hazard for other vehicles and increasing the risk of a crash.

Remedy: Tesla Service will inspect the light bar and install an additional mechanical attachment or replace the light bar using tape to adhere the light bar to the windshield as well as an additional mechanical attachment as necessary, free of charge. Interim owner notification letters explaining the safety risk were mailed December 26, 2025. Another notice will be sent once the remedy becomes available, ...

Summary: Tesla, Inc. (Tesla) is recalling certain 2024-2026 Cybertruck vehicles operating software prior to 2025.38.3. The vehicle controller software may cause the front parking lights to be too bright and exceed the maximum light output, adversely affecting the vision of other drivers. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."

Consequence: Parking lights that are too bright can reduce visibility of oncoming drivers, increasing the risk of a crash.

Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed December 12, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-00-008.

Summary: Tesla, Inc. (Tesla) is recalling certain 2024-2025 Cybertruck vehicles. The light bar can delaminate and detach from the vehicle.

Consequence: A detached light bar can become a road hazard, increasing the risk of a crash.

Remedy: Tesla service will replace the cant rail assembly, free of charge. Owner notification letters were mailed September 19, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-25-10-001.

Summary: Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck, 2017-2025 Model 3, and 2020-2025 Model Y vehicles. The tire pressure monitoring system (TPMS) warning light may not remain illuminated between drive cycles, failing to warn the driver of low tire pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 138, "Tire Pressure Monitoring Systems."

Consequence: Driving with improperly inflated tires increases the risk of a crash.

Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed February 15, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-018.

Summary: Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. A fault in the drive inverter may cause a loss of drive power to the wheels.

Consequence: A loss of drive power can increase the risk of a crash.

Remedy: Tesla service will replace the drive inverter, free of charge. Owner notification letters were mailed January 4, 2025. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-40-009.

Summary: Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. The rearview camera image may be delayed after shifting into reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."

Consequence: A delayed rearview image reduces the driver's view of what is behind the vehicle, increasing the risk of a crash.

Remedy: Tesla released an over-the-air (OTA) software update, free of charge. Owner notification letters were mailed November 25, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-016.

Summary: Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. The trunk bed trim sail applique could have been improperly adhered and can loosen.

Consequence: A loose applique can detach from the vehicle, creating a road hazard for following motorists and increasing the risk of a crash.

Remedy: Tesla service will apply adhesion promoter and pressure sensitive tape or replace missing applique as necessary, free of charge. Owner notification letters were mailed August 18, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-12-006.

Summary: Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. Excessive electrical current can cause the front windshield wiper motor controller to fail.

Consequence: Windshield wiper failure can reduce visibility, increasing the risk of a crash.

Remedy: Tesla service will replace the wiper motor, free of charge. Owner notification letters were mailed October 1, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-17-006.

Summary: Tesla, Inc. (Tesla) is recalling certain 2024 Cybertruck vehicles. The accelerator pedal pad may dislodge and cause the pedal to become trapped by the interior trim.

Consequence: A trapped accelerator pedal can cause the vehicle to accelerate unintentionally, increasing the risk of a crash.

Remedy: Tesla service will replace or repair the accelerator pedal assembly, free of charge. Owner notification letters were mailed June 18, 2024. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-33-003.

Summary: Tesla, Inc. (Tesla) is recalling certain 2012-2023 Model S, 2016-2024 Model X, 2017-2023 Model 3, 2019-2024 Model Y, and 2024 Cybertruck vehicles. An incorrect font size is displayed on the instrument panel for the Brake, Park, and Antilock Brake System (ABS) warning lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 105, "Hydraulic and Electric Brake Systems" and 135, "Light Vehicle Brake Systems."

Consequence: Warning lights with a smaller font size can make critical safety information on the instrument panel difficult to read, increasing the risk of a crash.

Remedy: Tesla began releasing an over-the-air (OTA) software update, free of charge. Owners may contact Tesla customer service at 1-877-798-3752. Tesla's number for this recall is SB-24-00-003.

at 46,500 miles, my AC charging dropped from the usual 48amps, down to 24amps. Then 2 days after this, my AC charging failed. This happened on 3/22/2026. I am unable to AC charge, but CAN DC charge. This is indicative of a PCS2 board failure, and this has been happening to a LOT of cybertrucks recently. It will be replaced under warranty (I hope) but so, so many vehicles are affected and ther...

Normal night charging . Morning I get into my car I have alerts PCS2 saying I can't charge anymore at home . This is a huge safety concern as it's happened to many Cybertruck owners. If we go on a trip we can literally be stranded due to range and accessibility of chargers with kids. This needs to be fixed as a constant warranty even past 50,000 miles as the vehicle is not proven and in its early...

On December 23, 2025, at approximately 9:45 AM, I was operating my Tesla Cybertruck with Autopilot engaged under normal driving conditions. There was no inclement weather, the roadway was straight, and visibility was clear. While driving, the vehicle suddenly veered off the main roadway without warning and traveled off-road, ultimately colliding with a tree. The movement was abrupt and not consis...

PCS2_a094 AC Charging unavailable This warning creates a situation of not be able to charge at all. Requiring a tow. I’ve was stranded with no way to charge. Had to leave my wife and kids cause I didn’t have enough charge to get them and get the truck back to a service center and another vehicle to get them home. Truck only a year old and 37k miles. Multiple owners reporting the same issue at a c...

Tesla sent me a Recall notice on the Lightbar, but in the notice, Tesla says it will not connect the lightbar to the electrical system and make the lightbar operable when Tesla repairs the defective lightbar. I paid $300.00 to have the original lightbar connected to the electrical system, and now, due to Tesla's improper installation, I am going to have to pay to have the new lightbar connected as...

Vehicle Safety Complaint - Tesla Cybertruck Steering System Failure During FSD While driving my Tesla Cybertruck with Full Self-Driving (FSD) engaged, the rear steering system failed without any prior warning. FSD immediately disengaged, and a red steering system ERROR appeared on the instrument cluster. The rear axle steering was completely disabled, turning radius became severely limited, and ve...

The side sails at the rear of the vehicle, lateral to the bed, are only adhered by double sided tape and can fall off while driving, causing damage to others. This has happened 2 times to my vehicle, it would ah element 3, but we stopped 1 from flying off

During my last wash of my cybertruck I noticed the cast aluminum wheel has a spoke that was completely cracked through. There was no violent pothole incident or collision to cause the crack. As an engineer I researched the method of manufacture and material of the rims. It is my opinion that the proper knock down factors were not used when designing these wheels for the 7,000 pound vehicle. Castin...

I have the Foundation Cyberbeast, the model which has an OEM light bar on windshield. While driving on 2-22-2026 at approximately 3:30 pm on the 5 freeway near Santa Ana, the appx 4 ft long light bar flew off and ricocheted violently on vehicle, while still attached by the power cord. This damaged many parts of my vehicle, specifically the glass roof, front windshield, and various body components ...

The PCS2 threw an alert that the Cybertruck could no longer charge with AC, but I was unable to do DC charging either. The truck is now a brick. Had I been out of town this would have been a serious safety issue. Think of it as an ICE car not being able to be filled at a gas station.

Since the release of V14, the Full Self-Driving (FSD) system automatically defaults to operating approximately 7 MPH above the posted speed limit. This occurs on all road types, including city streets and highways. When FSD is engaged, the vehicle sets the cruising speed above the detected speed limit without driver input. There is no setting that allows the driver to enforce strict compliance wi...

One day my car would not charge. At all. Luckily, I was at home when this happened, but had it happened to me or worse, my wife it could've been a very scary or dangerous situation. Either one of us could've been stuck with no way of charging. It's like a gas car with no way of putting gas in. The car would not charge from home or other chargers, including Tesla superchargers. When I described...

The rear passenger-side seat belt retractor is malfunctioning. The seat belt does not properly retract or maintain tension during normal use. The belt remains loose and does not snugly secure the passenger unless manually adjusted multiple times, reducing the effectiveness of the restraint system. This seat is regularly used by a child passenger. Because the seat belt does not function as designe...

All the road safety features stopped working all of a sudden. Auto lights. Defaulted to high beams. Lane departure stopped, cruise control stopped, forward emergency braking stopped, rear cross traffic stopped, blind stopped stopped, and other safety’s I am not sure of.

While operating on a public roadway with Tesla Full Self-Driving (Supervised) engaged, the vehicle unexpectedly departed its intended roadway trajectory. Upon recognizing unsafe vehicle behavior, I attempted to manually override and disengage the system using normal driver control inputs. Despite these attempts, the system did not disengage or yield control in a timely or effective manner. The veh...

On December 23, 2025, my 2024 Tesla Cybertruck (Foundation Series) was operating with Full Self-Driving (FSD – Supervised) engaged. While FSD was active, the vehicle executed an unsafe driving trajectory. I attempted to intervene and regain control; however, the system did not disengage as expected and did not yield control appropriately to driver input. Despite driver intervention attempts, the...

At approximately 6:30 PM on January 4, I experienced an incident where the passenger front door unlatched, completely by itself without pressing the unlatched button or pulling the manual release. It has since opened itself again in my driveway. And this can be a very serious issue if it worked to unlatch while driving and the door swings open and causes an accident or hits an object or person whi...

The contact owns a 2024 Tesla Cybertruck. The contact stated that while driving at a moderate speed on a windy day, a metal piece, approximately 2-3 ft. long and located on the side of the sunroof, detached from the vehicle. The contact managed to recover the piece that detached from the vehicle. The vehicle was taken to a Tesla service center, where the failure was acknowledged the failure, and ...

I believe there was an issue with the ABS system that kept me from stopping the vehicle, as speed was increasing while going downhill with the brake pedal pushed hard. I was forced to make the choice to steer the vehicle into a mountainside to stop it before I ended up over the side of the mountain road. The vehicle then tipped over, coming to a stop.

While driving on a local road and thank fully at speed of 20mph vehicle lost all power, in few seconds of alerts steering failed as well as brake failed. Car slowly coasted to stop and died completely. Steering and brakes were completely unresponsive all of a sudden while driving. Was only able to get out of car via emergency exit. If this was on a highway at highway speed am very positive it woul...

Component: Electrical System:Adas:Driver Monitoring:Software

Opened 2024-04-25

The Office of Defects Investigation (ODI) is opening a Recall Query to assess the remedy adequacy of Recall 23V838. On December 12, 2023, Tesla filed a Defect Information Report (Recall 23V838) applicable to all Tesla models produced and equipped with any version of its Autopilot system, which Tesla described as an SAE Level 2 (L2) Advanced Driver Assistance System (ADAS). Autopilot is the simultaneous engagement of Tesla’s Traffic-Aware Cruise Control (TACC) and Autosteer. In describing the saf...

Component: Electrical System:Adas

Opened 2025-10-07

The Office of Defects Investigation (“ODI”) is opening this Preliminary Evaluation (PE) to assess the scope, frequency, and potential safety consequences of FSD executing driving maneuvers that constitute traffic safety violations. This investigation concerns versions of FSD that Tesla has labeled as "FSD (Supervised)" and "FSD (Beta)." Tesla characterizes FSD as an SAE Level 2 partial automation system requiring a fully attentive driver who is engaged in the driving task at all times. Level 2 par...

Component: Electrical System:Adas

Opened 2024-10-17 · Closed 2026-03-18

On October 17, 2024, NHTSA’s Office of Defects Investigation (ODI) opened a Preliminary Evaluation (PE24031) of Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) to assess: the ability of the FSD system to detect and respond appropriately to reduced roadway visibility conditions; whether any other FSD crashes had occurred under degraded roadway visibility conditions that are similar in nature to the four SGO-reported crashes identified in the opening document,...

Component: Electrical System:Adas

Opened 2026-03-18

The Office of Defects Investigation (ODI) is opening this Engineering Analysis to evaluate Tesla’s Full Self Driving Beta and Full Self Driving (Supervised) (collectively, FSD) degradation detection system. The focus of this investigation will be to assess the system’s ability, when encountering reduced roadway visibility conditions, to detect degradation and alert the driver with sufficient time to respond. ODI will evaluate the performance of FSD in degraded roadway conditions and the updates ...